Model 3100 Series
Forma Series II Water Jacket CO
2
Incubator
Operating and Maintenance Manual 7043110 Rev. 13
Thermo Scientific
Thermo Scientific
Preface
Water Jacketed CO2 Incubator i
Preface
Table 1. Single Chamber Models
Model
CO
2
Sensor*
O
2
Voltage**
3110 T/C No 115
3111 T/C No 230
3120 IR No 115
3121 IR No 230
3130 T/C Yes 115
3131 T/C Yes 230
3140 IR Yes 115
3141 IR Yes 230
*T/C is a thermal conductivity sensor.
IR is an infrared sensor.
**All units are 50/60 Hz.
MANUAL NUMBER 7043110
13
24612/IN-3792
8/12/10
Updated schematics w ith VWR models
ccs
12
25584
8/5/09
Updated RH low alarm ringback time from 30 to 15 minutes
ccs
11
25248/IN3945
6/09/09
Updated drawer specs
- sliding and stationary
ccs
10
25020/IN-3881
4/27/09
Updated 3110-201-1 to rev 10, pg 8-5 & 8-6, updated elec schematics
ccs
--
25118/IN-3881
4/27/09
Gasket part number from 103065 to 191534, pg 8-1
ccs
9
25359/IN-3913
3/11/09
Updated part number of inner heated door to 190730 from 190630
ccs
8
25301/25303
2/16/09
Updated motor part number in Spare Parts list from 156126 to 1900071, UL decom ccs
7
24975
12/10/08
Updated water specs on pages 1-10 and 1-11
ccs
Thermo Scientific
Water Jacketed CO
2
Incubator ii
Thermo Scientific
Preface
Important Read this instruction manual.
Failure to read, understand and follow the instructions in this manual
may result in damage to the unit, injury to operating personnel, and poor equipment performance.
▲
Caution All internal adjustments and maintenance must be performed by qualified service personnel.
▲
Material in this manual is for information purposes only. The contents and the product it describes are subject to
change without notice. Thermo
Scientific makes no representations or warranties with respect to this manual.
no event shall Thermo be held liable for any damages, direct or incidental, arising out
of or related to the use of
this manual.
©2003 Thermo
Scientific. All rights reserved.
Thermo Scientific
iii
Water Jacketed CO
2
Incubator
Thermo Scientific
Preface
Important operating and/or maintenance instructions. Read the accompanying text carefully.
Potential electrical hazards. Only qualified persons should perform procedures associated with this
symbol.
Equipment being maintained or serviced must be turned off and locked off to prevent possible injury.
Hot surface(s) present which may cause burns to unprotected skin, or to materials which may be
damaged by elevated temperatures.
Marking of electrical
and electronic equipment, which applies to electrical and electronic equipment
falling under the Directive 2002/96/EC (WEEE) and the equipment that has been put on the market
after 13 August 2005.
This product is required to comply with the European Union’s Waste Electrical & Electronic
Equipment (WEEE) Directive 2002/96/EC. It is marked with the WEEE symbol. Thermo
Scientific
has contracted with one or more recycling/disposal companies in each EU Member State European
Country, and this product should be disposed of or recycled through them. Further information on
Thermo’s compliance with this directive, the recyclers in your country
and information on Thermo
products will be available at www.thermo.com.
✔ Always use the proper protective equipment (clothing, gloves, goggles, etc.)
✔ Always dissipate extreme cold or heat and wear protective clothing.
✔ Always follow good hygiene practices.
✔ Each individual is responsible for his or her own safety.
Thermo Scientific
Water Jacketed CO2 Incubator iv
Thermo Scientific
Preface
Do You Need Information or Assistance on
Thermo Scientific Products?
If you do, please contact us 8:00 a.m. to 6:00 p.m. (Eastern Time) at:
1-740-373-4763
Direct
1-800-438-4851
Toll Free, U.S. and Canada
1-877-213-8051
FAX
http://www.thermoscientific.com
Internet Worldwide Web Home Page
Service
E-Mail Address
Thermo Fisher Scientific
401 Millcreek Road, Box 649
Marietta, OH 45750
Our
staff can provide information on pricing and give you quotations. We can
take your order and provide delivery information on major equipment items or make
arrangements to have your local sales representative contact you. Our products are listed on the
Internet and we can be contacted through our Internet home page.
Our
staff can supply technical information about proper setup, operation or
troubleshooting of your equipment. We can fill your needs for
spare or replacement parts or
provide you with on-site service. We can also provide you with a quotation on our Extended
Warranty for your Thermo Scientific products.
Whatever Thermo Scientific products you need or use, we will be happy to discuss your
applications. If you are experiencing technical problems, working together, we will help you
locate
the problem and, chances are, correct it yourself...over the telephone without a service
call.
When more extensive service is necessary, we will assist you with direct factory trained
technicians or a qualified service organization for on-the-spot repair. If your service need is
covered by the warranty, we will arrange for the unit to be repaired
at our expense and to your
satisfaction.
Regardless of your needs, our professional telephone technicians are available to assist you
Monday through Friday from 8:00 a.m. to 6:00 p.m. Eastern Time. Please contact us by
telephone or fax. If you wish to write, our mailing address is:
International customers, please contact your local Thermo Scientific distributor.
Sales Support
Service Support
service.led.marietta@thermofisher.com